Bids Are invited for Repair, Maintenance, And Installation Of Plant/ Systems/Equipments (Version 2) - Onboar ... in India

Work Detail

Bids Are invited for Repair, Maintenance, And Installation Of Plant/ Systems/Equipments (Version 2) - Onboard Yardcrafts At Nd(Mbi); Ra/Pa Maintenance Of Cummins Make Engine, Model Kta 19M2 Fitted Onboard Various Yardcraft For 02 Years; Service Provider - Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak)Services Charges For 1500 Hourly Routines - Kta 19M2(I) Check Engine Log Book And Advise Ship Crew.(Ii) Remove Tappet Covers & Replace Tappet Cover Gasket.(Iii) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014, Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)].(Iv) Run The Engine For Three To Five Minutes For Prime The Lubricating Oil System.(V) Stop The Engine. Drain The Lubricating Oil From The Bottom Plug Of The Engine.(Vi) Replace Lubricating Oil Filter & Fuel Filter.(Vii) Open & Rip The Filter Elements.(Viii) Inspect & Check For Any Metal Particle Inside The Paper Filter Elements, Visual Inspection.(Ix) Clean Engine Breather.(X) Top Up The Engine Oil Up To H Level. (Oil Level Above ‘H Will Cause Hard Starting & Over Heating A Level Below ‘L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick).(Xi) Remove Air Cleaner & Turbocharger Air Intake Connections & Cross Over. Check Turbocharger Freeness Visually. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.)(Xii) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015(Xiii) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: Mixture Of Water: Ethylene Glycol (1:1) = 50% + 50%. If The Coolant Is Not Clean It Will Lead To Entry Of Foreign Particles And Rust Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Head Gasket Burning).(Xiv) Drain Water Sediments From Diesel Tank.(Xv) Check H.E Top Tank Cap Is In Place.(Xvi) Start The Engine And Check All Gauges, Replace If Require.(Xvii) Check For Any Oil/Water Leakage.(Xviii) Stop The Engine And Recheck Engine Oil Level, Top Up If Require.(Xix) Check For Exhaust Leakage And Advise Ship Crew.(Xx) After Necessary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Out Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters. , Materials For 1500 Hourly Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak - Ii) (1) Gasket,Rocker Lever Cover (Part No. 4920076) , Separator,Fuel Water (Part No. 4095190) , Filter, Oil Bypass (Part No. 3889311) , Element,Lub Oil Filter (Part No. 3166554) , Element,Air Cleaner (Part No. 3018042) , Kit,Coolant Test (Part No. 3167226) , Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak -Ii) Services Charges For 6000 Hourly Routines - Kta 19M2 (I) Check Engine Log Book And Advise Ship Staff. (Ii) Remove Injectors. Clean, Inspect, Repair & Calibrate With New Spares. (Iii) Remove Fuel Pt Pump. Clean, Inspect, Calibration & Repairs With New Spare Parts. (Iv) Remove Turbocharger. Clean, Inspect & Repair With New Repair Kit New Spare Parts. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.) (V) Assemble The Engine With Calibrated & Repaired Above Sub Assemblies. (Vi) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014 & Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)]. (Vii) Replace Lubricating Oil Filter & Fuel Filter. (Viii) Open & Rip The Filter Elements. (Ix) Inspect & Check For Any Metal Particle Inside The Paper Filter Elements, Visual Inspection. (X) Clean Engine Breather. (Xi) Tighten Nut & Cap Screw Of Air Inlet And Exhaust System. (Xii) Check Vibration Damper Visually. (Xiii) Check Belt Tension. (Xiv) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015. (Xv) Check (Cut Out) Safety Controls Such As High Water Temp, Low Lubricating Oil Pressure & Over Speed. (Xvi) Top Up The Engine Oil Up To H Level. (Oil Level Above ‘H Will Cause Hard Starting & Over Heating A Level Below ‘L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick) (Xvii) Flush Cooling System With Restore Plus, Run Engine To Bring It To Operating Temp. Stop The Engine Re Flush Cooling System With Potable Water Two To Three Times. Refill Cooling System With Coolant. (Xviii) Drain Water Sediments From Diesel Tank. (Xix) Check H.E. Top Tank Cap Is In Place. (Xx) Start The Engine And Check All Gauges, Replace If Require. (Xxi) Check For Any Oil/Water Leakage (Xxii) Stop The Engine And Recheck Engine Oil Level, Top Up If Require. (Xxiii) Check For Exhaust Leakage And Advise Ship Crew. (Xxiv) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: Mixture Of Water: Ethylene Glycol (1:1) = 50% + 50%. If The Coolant Is Not Clean It Will Lead To Entry Of Foreign Particles And Rust Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Head Gasket Burning). (Xxiv) After Necessary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Out Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters , Materials For 6000 Hourly Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak) 1St Year Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Valve,Shutoff (Part No. 3035346) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , (72 Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Element,Oil Bypass Filter (Part No. 3889311) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Seal,O Ring (Part No. 68910) , Element,Lub Oil Filter (Part No. 3166554) , Seal,O Ring (Part No. 145607) , Seal,Rectangular Ring (Part No. 173368) , Element,Air Cleaner (Part No. 3018042) , Gasket,Rocker Lever Cover (Part No. 4920076) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Inhibitor,Corrosion (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak- Ii) Services Charges For 12000 Hourly Routines - Kta 19M2 (I) Carry Out Prelimibary Trials Of Top Overhaul. (Ii) Observe, Study Engine Performance, Maintenance Practices Before Opening The Engine. (Iii) Check Engine Logbook And Advise Ship Staff. (Iv) Drain Oil From Oil Pan And Coolant From Cooling System. (V) Remove Turbochargers Connections. Clean, Inspect & Repair With New Spares. (Vi) Remove Turbocharger. Clean, Inspect & Repair With New Repair Kit New Spare Parts. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.) (Vii) Remove Intake Manifold. Clean, Inspect & Assemble With New Spare Parts. (Viii) Remove Exhaust Manifolds. Clean & Pressure Test. (Ix) Remove Rocker Housing, Rocker Leavers & Shaft. Clean, Inspect & Repair With New Spares. (X) Remove Injectors. Clean, Inspect, Repair & Calibrate With New Spares. (Xi) Water Manifold. Clean, Inspect & Assemble With New Spares. (Xii) Remove Fuel Manifold & Connections. Clean, Inspect & Assemble With New Spares. (Xiii) Remove Push Roads. Clean, Inspect. Replace If Required. (Xiv) Remove Cam Follower Housing & Cam Followers. Inspect Cam Shaft Lobs & Cam Roller. Clean & Repair With Spares. (If Found Any Abnormality In Cam Shaft, Replacement Of Camshaft Service Charges & Spares Will Be Extra Cost. Not Covered In 8K Routine.) (Xv) Remove Fuel Pt Pump. Clean, Inspect, Calibration & Repairs With New Spare Parts. (Xvi) Dismantle All Cylinder Heads. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Valves, Valve Guides, Valve Seat, Valve Insert, Valve Spring, Collate) (Xvii) Dismantle Heat Exchanger. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Heat Exchanger Element Does Not Quote In 8K Routine.) (Xviii) Dismantle Thermostat Hosing & Thermostat. Clean, Inspect & Repairs With New Spare Parts. (Xix) Dismantle Oil Cooler. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Xx) Dismantle All Pistons & Connecting Rods Assembly. Clean, Inspect & Repairs With New Spare Parts. (All Piston Rings, All Connecting Rods Bolts & Connecting Rod Bearings.) (Xxi) Dismantle One Liner For Inspect Corrosion / Pitting On Outside Diameter. Check All The Liners Inside Diameter For Ovality Without Dismantle Liners. (If Found Pitting/ Corrosion Of Withdraw Liners, We Will Withdraw All Liners & Inspect Pittiing/ Corrosion At Extra Cost Only One Liner & O-Rings Cover In 8K Routine.) (Xxii) Measure Crank Pin Diameter For Ovality Measurement And Check Crank Shaft End Play (Xxiii) Remove Water Pump. Clean, Inspect & Repairs With New Spare Parts. (Xxiv) Remove Sea Water Pumps. Clean, Inspect & Repairs With New Spare Parts ( Major Repair Kit.) (Xxv) Check Vibration Damper Visually. (Xxvi) Check All Hoses Of Cooling System. (Xxvii) Check All Hoses Of Air System. (Xxviii) Check All Hoses Of Lubricating Oil Systems. (Xxix) Check All Hoses Of Fuel Systems. (Xxx) Replace Filters Fuel, Oil Filters & Bypass Filters. (Xxxi) Replace Zinc Plugs. (Xxxii) Check / Tighten All Foundation Bolts (Xxxiii) Clean All Dismantle Parts And Cylinder Block Top Portion. (Xxxiv) Assemble The Engine With All New Gasket Sets, O Rings, Seals And Above Dismantle Sub Assemblies. (Xxxv) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014, Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)]. (Xxxvi) Change Air Cleaner Element. (Xxxvii) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015. (Xxxviii) Check The Safetry Parameters Such As Engine Coolant Temp, Low Oil Pressure And Over Speed. (Xxxix) Once The Engine Is Assembled. Fill New Engine Oil; Maintain Oil Level At H Mark. (Oil Level Above H Will Cause Hard Starting & Overheating A Level Below L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick) (Xl) Check H.E. Top Tank Cap Is In Place. (Xli) Drain Water Sediments From Diesel Tank. (Xlii) Primed The Fuel System. (Xliii) Start The Engine And Check All Gauges, Replace Them If Required. (Xliv) Check For Any Oil/ Water Leakage. (Xlv) Stop The Engine And Recheck Engine Oil Level, Top Up If Required. (Xlvi) Check For Exhaust Leakage And Advise Ship Crew. (Xlvii) Flush Cooling System With Restore Plus, Run Engine To Bring It To Operating Temp. Stop The Engine Re Flush Cooling System With Potable Water Two To Three Times. Refill Cooling System With Coolant. (Xlviii) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: It Is Supplied In Plastic Red Colour Containers Having Different Part Nos. For Different Volumes. The Colour Of The Coolant Additive Concentrate Is Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Heat Gasket Burning). (Xlix) After Neccesary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Oout Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters. , Materials For 12000 Hourly Routines For 1St Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak) 1St Year (1) Stud (Part No. 3393130) , Gasket,Exhaust Manifold (Part No. 3043097) , Hose,Plain (Part No. 3331403) , Clamp,T Bolt (Part No. 306809) , Kit,Liner (Part No. 4024767) , Nozzle,Piston Cooling (Part No. 3897840) , Seal,O Ring (Part No. 3866096) , Washer,Plain (Part No. 3025485) , Screw,Twelve Point Cap (Part No. 3025482) , Bushing (Part No. 3002834) , Gasket,Connection (Part No. 3085804) , Seal,O Ring (Part No. 145607) , Seal,O Ring (Part No. 3081695) , Gasket,Tor Cnv Cooler (Part No. 3065791) , Gasket,Oil Cooler Core (Part No. 206973) , Draincock (Part No. S 923 E) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 145540) , Gasket,Lub Oil Clr Hsg (Part No. 3065790) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Gasket,Hand Hole (Part No. 3042586) , Seal,O Ring (Part No. 3046201) , Gasket,Hand Hole (Part No. 3042586) , Screw, Captive Washer Cap (Part No. 3040838) , Damper,Viscous Vibration (Part No. 3081040) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Filter,Oil Bypass (Part No. 3889311) , Shaft,Cam Follower (Part No. 3078218) , Lever,Cam Follower (Part No. 3039164) , Lever,Cam Follower (Part No. 3642503) , Ring,Retaining (Part No. 205439) , Washer,Plain (Part No. 127362) , Screw,Cam Follower Shaft (Part No. 3002886) , Rod,Push (Part No. 3017961) , Rod,Push (Part No. 3057139) , Crosshead,Valve (Part No. 3086362) , Washer,Plain (Part No. 205059) , Screw,Fracture Resistant (Part No. 3032633) , Gasket,Rocker Lever Cover (Part No. 3629140) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Gasket,Thermostat Housing (Part No. 3085803) , Thermostat (Part No. 3076489) , Seal,Thermostat (Part No. 188318) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3037537) , Seal,O Ring(Part No. 3028291) , Seal,Thermostat (Part No. 186780) , Thermostat (Part No. 4000464) , Screw,Captive Washer Cap (Part No. 3408216) , Screw,Captive Washer Cap (Part No. 3012472) , Indicator,Restriction (Part No. 3637209) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Hose,Flexible (Part No. Ak10027 Ss) , Gasket,Cover Plate (Part No. 3230948) , Seal,O Ring (Part No. 68910) , Ball (Part No. 3230964) , Seal,O Ring (Part No. 3029820) , Gasket,Cover Plate (Part No. 2884961) , Element,Lub Oil Filter (Part No. 3166554) , Gasket,Oil Trf Connection (Part No. 3228333) , Seal,O Ring (Part No. 33201125) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3036666) , Seal,O Ring (Part No. 3084539) , Draincock (Part No. 214345) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3046201) , Hose,Plain (Part No. 3818271) , Clamp,Hose (Part No. 209773) , Seal,O Ring (Part No. 3035026) , Seal,O Ring (Part No. 3028291) , Hose,Flexible (Part No. 3349292) , Washer,Plain (Part No. 127018) , Screw,Twelve Point Cap (Part No. 3001811) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 3001340) , Seal,Grommet (Part No. S 1098) , Valve,Check (Part No. 3028324) , Valve,Check (Part No. 3028325) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Seal,O Ring (Part No. 3028291) , Clamp,Hose (Part No. 43828 C) , Hose,Plain (Part No. 63241 F) , Seal,O Ring (Part No. 3028291) , Draincock (Part No. S 962 E) , Hose,Plain (Part No. 3818268) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 3028291) , Hose,Plain (Part No. 3063240) , Clamp,Hose (Part No. 43828 C) , Seal,O Ring (Part No. 3330159) , Gasket,Oil Pan (Part No. 3042590) , Cap,Filler (Part No. 500181) , Gasket,Adapter (Part No. 3073213) , Plug,Pipe (Part No. S 911 B) , Plug,Pipe (Part No. S 911 A) , Plug,Expansion (Part No. 203933) , Plug,Expansion (Part No. 206224) , Plug,Expansion (Part No. 205401) , Insert,Valve (Part No. 3086193) , Pin,Groove (Part No. 3635250) , Guide,Valve Stem (Part No. 3202210) , Insert,Valve (Part No. 3086192) , Valve,Intake (Part No. 3052820) , Valve,Exhaust (Part No. 3088389) , Rotator,Valve (Part No. 3640315) , Spring,Valve (Part No. 5559727) , Collet,Valve (Part No. 205091) , Retainer,Valve Spring (Part No. 205094) , Kit,Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3650900) , Kit,Piston Rings (Part No. Kit2865146) , Sleeve,Wear (Part No. 190397) , Kit Major Repait (Part No. 3897385) , Seal,O Ring (Part No. 3897787) , Seal,O Ring (Part No. 3033248) , Resistor,Corrosion (Part No. 4058965) , Valve,Shutoff (Part No. 179901) , Hose,Plain (Part No. 179931) , Clamp,Hose (Part No. 179904) , Valve,Float (Part No. Ar 8629) , Float (Part No. 201022) , Seal,Rectangular Ring (Part No. 3072430) , Screen Fuel Filter (Part No. 154277) , Breather,Fuel Tank (Part No. 68982) , Seal,Grommet (Part No. 206808) , Gasket,Connection (Part No. 3001305) , Retainer,Seal (Part No. 3001301) , Gasket,Connection (Part No. 3032161) , Valve,Shutoff (Part No. 3035346) , Seal,O Ring (Part No. 3279794) , Hose,Flexible (Part No. 3035580) , Bearing,Ball (Part No. S 16002) , Bearing,Ball (Part No. S 16069) , Ring,Retaining (Part No. 70183) , Shaft,Water Pump (Part No. 3042827) , Seal,Oil (Part No. 206948) , Seal,Water Pump (Part No. 4397228) , Impeller,Water Pump (Part No. 205243) , Draincock (Part No. S 962 E) , Ring,Retaining (Part No. 205258) , Connection,Water Inlet (Part No. 3229546) , Brace,Water Pump (Part No. 3036096) , Seal,O Ring (Part No. 145623) , Washer,Plain (Part No. 3005594) , Washer,Lock (Part No. S 604) , Screw,Hexagon Head Cap (Part No. S 103 D) , Screw,Hexagon Head Cap (Part No. S 137) , Screw,Hexagon Head Cap (Part No. 108707) , Plug,Pipe (Part No. S 995) , Gasket,Water Pump (Part No. 3202283) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Housing,Tur Bearing (Part No. 3594555) , Rotor,Shaft Wheel (Part No. 3521033) , Shield,Turbocharger Heat (Part No. 3536588) , Diffuser,Turbocharger (Part No. 3538455) , Inhibitor,Corrosion 10 Liters (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Kit,Lower Engine Gasket (Part No. 4376512) , Kit,Upper Engine Gasket (Part No. 4352578) , Breakdown Services Maintenance For 1St Year - Engine Model Kta 19M2 Services - Breakdown Call Visits (No. Of Days In A Year) , Breakdown Part Maintenance For 1St Year - Engine Model Kta 19M2 Materials - (1) Stud,Double End Plain (Part No. 3393130) , Gasket,Exhaust Manifold (Part No. 3043097) , Hose,Plain (Part No. 3331403) , Clamp,T Bolt (Part No. 3063809) , Kit,Liner (Part No. 4024767) , Nozzle,Piston Cooling (Part No. 3897840) , Seal,O Ring (Part No. 3866096) , Washer,Plain (Part No. 3025485) , Screw,Twelve Point Cap (Part No. 3025482) , Bushing (Part No. 3002834) , Cleaner,Air (Part No. 4095069) , Gasket,Connection (Part No. 3085804) , Seal,O Ring (Part No. 145607) , Seal,O Ring (Part No. 3081695) , Gasket,Tor Cnv Oil Cooler (Part No. 3065791) , Gasket,Oil Cooler Core (Part No. 206973) , Draincock (Part No. S 962 E) , Kit,Oil Cooler (Part No. 3804934) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 145540) , Gasket,Lub Oil Clr Hsg (Part No. 3065790) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Gasket,Hand Hole (Part No. 3042586) , Seal,O Ring (Part No. 3046201) , Gasket,Hand Hole (Part No. 3042586) , Screw,Captive Washer Cap (Part No. 3040838) , Damper,Viscous Vibration (Part No. 3081040) , Core,Heat Exchanger (Part No. 4019516) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Filter, Oil Bypass (Part No. 3889311) , Shaft,Cam Follower (Part No. 3078218) , Lever,Cam Follower (Part No. 3039164) , Lever,Cam Follower (Part No. 3642503) , Ring,Retaining (Part No. 205439) , Washer,Plain (Part No. 127362) , Screw,Cam Follower Shaft (Part No. 3002886) , Rod,Push (Part No. 3017961) , Rod,Push (Part No. 3057139) , Crosshead,Valve (Part No. 3086362) , Washer,Plain (Part No. 205059) , Screw,Fracture Resistant (Part No. 3032633) , Gasket,Rocker Lever Cover (Part No. 3629140) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Gasket,Thermostat Housing (Part No. 3085803) , Thermostat (Part No. 3076489) , Seal,Thermostat (Part No. 188318) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3037537) , Sensor,Temperature (Part No. 3865312) , Sensor,Temperature (Part No. 3865312) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3028291) , Seal,Thermostat (Part No. 186780) , Thermostat (Part No. 4000464) , Screw,Captive Washer Cap (Part No. 3408216) , Screw,Captive Washer Cap (Part No. 3012472) , Indicator,Restriction (Part No. 3637209) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Hose,Flexible (Part No. Ak10027 Ss) , Gasket,Cover Plate (Part No. 3230948) , Seal,O Ring (Part No. 68910) , Ball (Part No. 3230964) , Seal,O Ring (Part No. 3029820) , Gasket,Cover Plate (Part No. 2884961) , Element,Lub Oil Filter (Part No. 3166554) , Gasket,Oil Trf Connection (Part No. 3228333) , Seal,O Ring (Part No. 3201125) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3036666) , Seal,O Ring (Part No. 3084539) , Draincock (Part No. 214345) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3046201) , Hose,Plain (Part No. 3818271) , Clamp,Hose (Part No. 209773) , Seal,O Ring (Part No. 3035026) , Seal,O Ring (Part No. 3028291) , Washer,Plain (Part No. 127018) , Screw,Twelve Point Cap (Part No. 3001811) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 3001340) , Seal,Grommet (Part No. S 1098) , Valve,Check (Part No. 3028324) , Valve,Check (Part No. 3028325) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Seal,O Ring (Part No. 3028291) , Clamp,Hose (Part No. 43828 C) , Hose,Plain (Part No. 63241 F) , Seal,O Ring (Part No. 3028291) , Draincock (Part No. S 962 E) , Hose,Plain (Part No. 3818268) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 3028291) , Hose,Plain (Part No. 3063240) , Clamp,Hose (Part No. 43828 C) , Sensor,Pressure (Part No. 5594397) , Sensor,Pressure (Part No. 5594397) , Seal,O Ring (Part No. 3330159) , Sensor,Engine Position (Part No. 4327234) , Module,Electronic Control (Part No. 4354558) , Sensor,Engine Position (Part No. 4327234) , Gasket,Oil Pan (Part No. 3042590) , Cap,Filler (Part No. 500181) , Gasket,Adapter (Part No. 3073213) , Plug,Pipe (Part No. S 911 B) , Plug,Pipe (Part No. S 915 A) , Plug,Expansion (Part No. 203933) , Plug,Expansion (Part No. 206224) , Plug,Expansion (Part No. 205401) , Insert,Valve (Part No. 3086193) , Pin,Groove (Part No. 3635250) , Guide,Valve Stem (Part No. 3202210) , Insert,Valve (Part No. 3086192) , Valve,Intake (Part No. 3052820) , Valve,Exhaust (Part No. 3088389) , Rotator,Valve (Part No. 3640315) , Spring,Valve (Part No. 5559727) , Collet,Valve (Part No. 205091) , Retainer,Valve Spring (Part No. 205094) , Kit,Engine Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3650900) , Kit,Piston Rings (Part No. Kit2865146) , Sleeve,Wear (Part No. 190397) , Kit,Minor Repair (Part No. 3897386) , Kit,Major Repair (Part No. 3897385) , Seal,O Ring (Part No. 3897787) , Seal,O Ring (Part No. 3033248) , Resistor,Corrosion (Part No. 4058965) , Valve,Shutoff (Part No. 179901) , Hose,Plain (Part No. 179931) , Clamp,Hose (Part No. 179904) , Tank,Fuel Transfer (Part No. Ar95856) , Valve,Float (Part No. Ar 8629) , Float (Part No. 201022) , Seal,Rectangular Ring (Part No. 3072430) , Screen Fuel Filter (Part No. 154277) , Breather,Fuel Tank (Part No. 68982) , Seal,Grommet (Part No. 206808) , Gasket,Connection (Part No. 3001305) , Retainer,Seal (Part No. 3001301) , Gasket,Connection (Part No. 3032161) , Turbocharger,Aftermarket (Part No. 4033483) , Valve,Shutoff (Part No. 3035346) , Seal,O Ring (Part No. 3279794) , Hose,Flexible (Part No. 3035580) , Bearing,Ball (Part No. S 16002) , Bearing,Ball (Part No. S 16069) , Ring,Retaining (Part No. 70183) , Shaft,Water Pump (Part No. 3042827) , Seal,Oil (Part No. 206948) , Seal,Water Pump (Part No. 4397228) , Impeller,Water Pump (Part No. 205243) , Draincock (Part No. S 962 E) , Ring,Retaining (Part No. 205258) , Connection,Water Inlet (Part No. 3229546) , Brace,Water Pump (Part No. 3036096) , Seal,O Ring (Part No. 145623) , Washer,Plain (Part No. 3005594) , Washer,Lock (Part No. S 604) , Screw,Hexagon Head Cap (Part No. S 103 D) , Screw,Hexagon Head Cap (Part No. S 137) , Screw,Hexagon Head Cap (Part No. 108707) , Plug,Pipe (Part No. S 995) , Gasket,Water Pump (Part No. 3202283) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Housing,Tur Bearing (Part No. 3594555) , Rotor,Shaft Wheel (Part No. 3521033) , Shield,Turbocharger Heat (Part No. 3536588) , Diffuser,Turbocharger (Part No. 3538455) , Inhibitor,Corrosion 10 Liters (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Kit,Lower Engine Gasket (Part No. 4376512) , Kit,Upper Engine Gasket (Part No. 4352578) , Harness,Etr Cnt Mdl Wrg (Part No. 3088290) , Pump,Sea Water (Part No. 3866609) , Camshaft (Part No. 3066882) , Bearing,Camshaft Thrust (Part No. 3007971) , Key,Offset Woodruff (Part No. 200709) , Kit,Turbocharger (Part No. 2882093) , Clamp,V Band (Part No. 3522631) , Core,Aftercooler (Part No. 4910355) , Sensor,Pressure (Part No. 5594397) , Sensor,Engine Position (Part No. 4327234) , Housing,Actuator (Part No. 3084728) , Injector (Part No. 4307428) , Kit,Oil Cooler (Part No. 3804934) , Harness,Etr Cnt Mdl Wrg (Part No. 3088290) , Kit,Water Pump (Part No. 5633548) , Wire,Ground (Part No. 3018924) , Kit,Engine Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3047390) , Kit,Piston Rings (Part No. Kit2865146) , Kit,Liner (Part No. 4371769) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Gauge,Temperature (Part No. 4071818) , Hose,Flexible (Part No. Ak 4030 Ms) , Coupling,Plain Hose (Part No. 3069170) , Coupling,Plain Pipe (Part No. S 1059) , Elbow,Male Adapter (Part No. 68139) , Gauge,Temperature (Part No. 4071823) , Gauge,Pressure (Part No. 4071825) , Pickup,Magnetic (Part No. 4396219) , Harness,Wiring (Part No. 3875359) , Transducer (Part No. 3392445) , Isolator,Vibration (Part No. 102486) , Switch,Temperature (Part No. 4962857) , Switch,Pressure (Part No. 4962841) , Switch,Temperature (Part No. 4962840) , Switch,Temperature (Part No. 4962857) , Sensor,Temperature (Part No. 4926975) , Switch,Temperature (Part No. 4957690) , Valve,Fuel Shutoff (Part No. 3167975) , Tee,Female Pipe (Part No. 70802) , Nipple,Plain Pipe (Part No. S 945) , Bushing,Reducing Pipe (Part No. S 910 C) , Hose,Flexible (Part No. Ak 4016 Ss) , Hose,Flexible (Part No. Ak 4015 Ss) , Gasket,Exh Out Connection (Part No. 2880039) , Washer,Plain (Part No. S 640) , Connection,Exhaust Outlet (Part No. 4084138) , Gasket,Exh Out Connection (Part No. 2880039) , Gasket,Exh Out Connection (Part No. 2880040) , Gauge,Temperature (Part No. 4071818) , Gauge,Temperature (Part No. 4071823) , Gauge,Pressure (Part No. 4071825) , Gauge,Pressure (Part No. 4071832) , Gauge,Temperature (Part No. 4071831) , Gauge,Temperature (Part No. 4071829) , Isolator,Vibration (Part No. 102486) , Washer,Plain (Part No. 102484) , Switch,Push Button (Part No. 504395) , Switch,Key (Part No. 504975) , Switch,Toggle (Part No. 500278) , Coupling,Plain Pipe (Part No. S 1059) , Elbow,Male Adapter (Part No. 68139) , Hose,Flexible (Part No. Ak 4030 Ms) , Coupling,Plain Hose (Part No. 3069170) , Ammeter (Part No. 502881) , Gauge,Pressure (Part No. 4071832) , Gauge,Temperature (Part No. 4071829) , Gauge,Temperature (Part No. 4071831) , Ammeter (Part No. 502881) , Tachometer (Part No. 3231408) , Tachometer (Part No. 2879766) , Tachometer (Part No. 2879766) , Ammeter (Part No. 502881) , Harness,Wiring (Part No. 2865306) , Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak) Services Charges For 1500 Hourly Routines - Kta 19M2 (I) Check Engine Log Book And Advise Ship Crew. (Ii) Remove Tappet Covers & Replace Tappet Cover Gasket. (Iii) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014, Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)]. (Iv) Run The Engine For Three To Five Minutes For Prime The Lubricating Oil System. (V) Stop The Engine. Drain The Lubricating Oil From The Bottom Plug Of The Engine. (Vi) Replace Lubricating Oil Filter & Fuel Filter. (Vii) Open & Rip The Filter Elements. (Viii) Inspect & Check For Any Metal Particle Inside The Paper Filter Elements, Visual Inspection. (Ix) Clean Engine Breather. (X) Top Up The Engine Oil Up To H Level. (Oil Level Above ‘H Will Cause Hard Starting & Over Heating A Level Below ‘L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick). (Xi) Remove Air Cleaner & Turbocharger Air Intake Connections & Cross Over. Check Turbocharger Freeness Visually. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.) (Xii) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015 (Xiii) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: Mixture Of Water: Ethylene Glycol (1:1) = 50% + 50%. If The Coolant Is Not Clean It Will Lead To Entry Of Foreign Particles And Rust Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Head Gasket Burning). (Xiv) Drain Water Sediments From Diesel Tank. (Xv) Check H.E Top Tank Cap Is In Place. (Xvi) Start The Engine And Check All Gauges, Replace If Require. (Xvii) Check For Any Oil/Water Leakage. (Xviii) Stop The Engine And Recheck Engine Oil Level, Top Up If Require. (Xix) Check For Exhaust Leakage And Advise Ship Crew. (Xx) After Necessary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Out Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters. , Materials For 1500 Hourly Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak - Ii) (1) Gasket,Rocker Lever Cover (Part No. 4920076) , Separator,Fuel Water (Part No. 4095190) , Filter, Oil Bypass (Part No. 3889311) , Element,Lub Oil Filter (Part No. 3166554) , Element,Air Cleaner (Part No. 3018042) , Kit,Coolant Test (Part No. 3167226) , Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak -Ii) Services Charges For 6000 Hourly Routines - Kta 19M2 (I) Check Engine Log Book And Advise Ship Staff. (Ii) Remove Injectors. Clean, Inspect, Repair & Calibrate With New Spares. (Iii) Remove Fuel Pt Pump. Clean, Inspect, Calibration & Repairs With New Spare Parts. (Iv) Remove Turbocharger. Clean, Inspect & Repair With New Repair Kit New Spare Parts. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.) (V) Assemble The Engine With Calibrated & Repaired Above Sub Assemblies. (Vi) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014 & Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)]. (Vii) Replace Lubricating Oil Filter & Fuel Filter. (Viii) Open & Rip The Filter Elements. (Ix) Inspect & Check For Any Metal Particle Inside The Paper Filter Elements, Visual Inspection. (X) Clean Engine Breather. (Xi) Tighten Nut & Cap Screw Of Air Inlet And Exhaust System. (Xii) Check Vibration Damper Visually. (Xiii) Check Belt Tension. (Xiv) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015. (Xv) Check (Cut Out) Safety Controls Such As High Water Temp, Low Lubricating Oil Pressure & Over Speed. (Xvi) Top Up The Engine Oil Up To H Level. (Oil Level Above ‘H Will Cause Hard Starting & Over Heating A Level Below ‘L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick) (Xvii) Flush Cooling System With Restore Plus, Run Engine To Bring It To Operating Temp. Stop The Engine Re Flush Cooling System With Potable Water Two To Three Times. Refill Cooling System With Coolant. (Xviii) Drain Water Sediments From Diesel Tank. (Xix) Check H.E. Top Tank Cap Is In Place. (Xx) Start The Engine And Check All Gauges, Replace If Require. (Xxi) Check For Any Oil/Water Leakage (Xxii) Stop The Engine And Recheck Engine Oil Level, Top Up If Require. (Xxiii) Check For Exhaust Leakage And Advise Ship Crew. (Xxiv) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: Mixture Of Water: Ethylene Glycol (1:1) = 50% + 50%. If The Coolant Is Not Clean It Will Lead To Entry Of Foreign Particles And Rust Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Head Gasket Burning). (Xxiv) After Necessary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Out Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters , Materials For 6000 Hourly Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak) 2Nd Year (1) Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Valve,Shutoff (Part No. 3035346) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , (72 Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Element,Oil Bypass Filter (Part No. 3889311) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Seal,O Ring (Part No. 68910) , Element,Lub Oil Filter (Part No. 3166554) , Seal,O Ring (Part No. 145607) , Seal,Rectangular Ring (Part No. 173368) , Element,Air Cleaner (Part No. 3018042) , Gasket,Rocker Lever Cover (Part No. 4920076) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Inhibitor,Corrosion (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak- Ii) Services Charges For 12000 Hourly Routines - Kta 19M2 (I) Carry Out Prelimibary Trials Of Top Overhaul. (Ii) Observe, Study Engine Performance, Maintenance Practices Before Opening The Engine. (Iii) Check Engine Logbook And Advise Ship Staff. (Iv) Drain Oil From Oil Pan And Coolant From Cooling System. (V) Remove Turbochargers Connections. Clean, Inspect & Repair With New Spares. (Vi) Remove Turbocharger. Clean, Inspect & Repair With New Repair Kit New Spare Parts. (Check Turbocharger End Play And Radial Clearance At Every 1500Hours, Permissible Turbo End Play Is 0.002 To 0.005 And Radial Clearance Is 0.012 To .018 Failure To Check Turbo Will Lead To Similar Problems As Mentioned Above And Premature Turbo Failure.) (Vii) Remove Intake Manifold. Clean, Inspect & Assemble With New Spare Parts. (Viii) Remove Exhaust Manifolds. Clean & Pressure Test. (Ix) Remove Rocker Housing, Rocker Leavers & Shaft. Clean, Inspect & Repair With New Spares. (X) Remove Injectors. Clean, Inspect, Repair & Calibrate With New Spares. (Xi) Water Manifold. Clean, Inspect & Assemble With New Spares. (Xii) Remove Fuel Manifold & Connections. Clean, Inspect & Assemble With New Spares. (Xiii) Remove Push Roads. Clean, Inspect. Replace If Required. (Xiv) Remove Cam Follower Housing & Cam Followers. Inspect Cam Shaft Lobs & Cam Roller. Clean & Repair With Spares. (If Found Any Abnormality In Cam Shaft, Replacement Of Camshaft Service Charges & Spares Will Be Extra Cost. Not Covered In 8K Routine.) (Xv) Remove Fuel Pt Pump. Clean, Inspect, Calibration & Repairs With New Spare Parts. (Xvi) Dismantle All Cylinder Heads. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Valves, Valve Guides, Valve Seat, Valve Insert, Valve Spring, Collate) (Xvii) Dismantle Heat Exchanger. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Heat Exchanger Element Does Not Quote In 8K Routine.) (Xviii) Dismantle Thermostat Hosing & Thermostat. Clean, Inspect & Repairs With New Spare Parts. (Xix) Dismantle Oil Cooler. Clean, Inspect & Pressure Test. Assemble With New Spare Parts. (Xx) Dismantle All Pistons & Connecting Rods Assembly. Clean, Inspect & Repairs With New Spare Parts. (All Piston Rings, All Connecting Rods Bolts & Connecting Rod Bearings.) (Xxi) Dismantle One Liner For Inspect Corrosion / Pitting On Outside Diameter. Check All The Liners Inside Diameter For Ovality Without Dismantle Liners. (If Found Pitting/ Corrosion Of Withdraw Liners, We Will Withdraw All Liners & Inspect Pittiing/ Corrosion At Extra Cost Only One Liner & O-Rings Cover In 8K Routine.) (Xxii) Measure Crank Pin Diameter For Ovality Measurement And Check Crank Shaft End Play (Xxiii) Remove Water Pump. Clean, Inspect & Repairs With New Spare Parts. (Xxiv) Remove Sea Water Pumps. Clean, Inspect & Repairs With New Spare Parts ( Major Repair Kit.) (Xxv) Check Vibration Damper Visually. (Xxvi) Check All Hoses Of Cooling System. (Xxvii) Check All Hoses Of Air System. (Xxviii) Check All Hoses Of Lubricating Oil Systems. (Xxix) Check All Hoses Of Fuel Systems. (Xxx) Replace Filters Fuel, Oil Filters & Bypass Filters. (Xxxi) Replace Zinc Plugs. (Xxxii) Check / Tighten All Foundation Bolts (Xxxiii) Clean All Dismantle Parts And Cylinder Block Top Portion. (Xxxiv) Assemble The Engine With All New Gasket Sets, O Rings, Seals And Above Dismantle Sub Assemblies. (Xxxv) Carry Out Tappet Settings [Valve Setting Intake Valve Clearance Is 0.014, Exhaust Valve Clearance Is 0.027 & Injector Setting Screw Torque Is In-Lb (N. M.) 100 (11)]. (Xxxvi) Change Air Cleaner Element. (Xxxvii) Check Crankshaft End Play. It Should Be Between 0.005 To 0.015. (Xxxviii) Check The Safetry Parameters Such As Engine Coolant Temp, Low Oil Pressure And Over Speed. (Xxxix) Once The Engine Is Assembled. Fill New Engine Oil; Maintain Oil Level At H Mark. (Oil Level Above H Will Cause Hard Starting & Overheating A Level Below L Mark May Cause Engine Seizure. Make Sure The Equipment Is In Level. A Slight Angle May Give You A False Reading On The Dipstick) (Xl) Check H.E. Top Tank Cap Is In Place. (Xli) Drain Water Sediments From Diesel Tank. (Xlii) Primed The Fuel System. (Xliii) Start The Engine And Check All Gauges, Replace Them If Required. (Xliv) Check For Any Oil/ Water Leakage. (Xlv) Stop The Engine And Recheck Engine Oil Level, Top Up If Required. (Xlvi) Check For Exhaust Leakage And Advise Ship Crew. (Xlvii) Flush Cooling System With Restore Plus, Run Engine To Bring It To Operating Temp. Stop The Engine Re Flush Cooling System With Potable Water Two To Three Times. Refill Cooling System With Coolant. (Xlviii) Check Coolant For Proper Concentration, Check Coolant Hygiene & Top Up. (Added Coolant Must Be Clean And Treated As Follows: It Is Supplied In Plastic Red Colour Containers Having Different Part Nos. For Different Volumes. The Colour Of The Coolant Additive Concentrate Is Formation. This May Clog The Coolant Passages, Resulting In Overheating - Subsequently Leading To Piston Rings Block Damage And Heat Gasket Burning). (Xlix) After Neccesary Inspection Restart The Engine. Run At Idle Speed For Not More Than 5 Minutes; Carry Oout Load Trial On Ship Available Load. Observe The Engine Performance And Record The Engine Parameters. , Materials For 12000 Hourly Routines For 2Nd Year - Kta 19M2 (Fc Manoram, Fc Vihar, Fc Ankola, Oiler Fb-7 & Oiler Purak) 2Nd Year (1) Stud (Part No. 3393130) , Gasket,Exhaust Manifold (Part No. 3043097) , Hose,Plain (Part No. 3331403) , Clamp,T Bolt (Part No. 306809) , Kit,Liner (Part No. 4024767) , Nozzle,Piston Cooling (Part No. 3897840) , Seal,O Ring (Part No. 3866096) , Washer,Plain (Part No. 3025485) , Screw,Twelve Point Cap (Part No. 3025482) , Bushing (Part No. 3002834) , Gasket,Connection (Part No. 3085804) , Seal,O Ring (Part No. 145607) , Seal,O Ring (Part No. 3081695) , Gasket,Tor Cnv Cooler (Part No. 3065791) , Gasket,Oil Cooler Core (Part No. 206973) , Draincock (Part No. S 923 E) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 145540) , Gasket,Lub Oil Clr Hsg (Part No. 3065790) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Gasket,Hand Hole (Part No. 3042586) , Seal,O Ring (Part No. 3046201) , Gasket,Hand Hole (Part No. 3042586) , Screw, Captive Washer Cap (Part No. 3040838) , Damper,Viscous Vibration (Part No. 3081040) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Filter,Oil Bypass (Part No. 3889311) , Shaft,Cam Follower (Part No. 3078218) , Lever,Cam Follower (Part No. 3039164) , Lever,Cam Follower (Part No. 3642503) , Ring,Retaining (Part No. 205439) , Washer,Plain (Part No. 127362) , Screw,Cam Follower Shaft (Part No. 3002886) , Rod,Push (Part No. 3017961) , Rod,Push (Part No. 3057139) , Crosshead,Valve (Part No. 3086362) , Washer,Plain (Part No. 205059) , Screw,Fracture Resistant (Part No. 3032633) , Gasket,Rocker Lever Cover (Part No. 3629140) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Gasket,Thermostat Housing (Part No. 3085803) , Thermostat (Part No. 3076489) , Seal,Thermostat (Part No. 188318) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3037537) , Seal,O Ring(Part No. 3028291) , Seal,Thermostat (Part No. 186780) , Thermostat (Part No. 4000464) , Screw,Captive Washer Cap (Part No. 3408216) , Screw,Captive Washer Cap (Part No. 3012472) , Indicator,Restriction (Part No. 3637209) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Hose,Flexible (Part No. Ak10027 Ss) , Gasket,Cover Plate (Part No. 3230948) , Seal,O Ring (Part No. 68910) , Ball (Part No. 3230964) , Seal,O Ring (Part No. 3029820) , Gasket,Cover Plate (Part No. 2884961) , Element,Lub Oil Filter (Part No. 3166554) , Gasket,Oil Trf Connection (Part No. 3228333) , Seal,O Ring (Part No. 33201125) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3036666) , Seal,O Ring (Part No. 3084539) , Draincock (Part No. 214345) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3046201) , Hose,Plain (Part No. 3818271) , Clamp,Hose (Part No. 209773) , Seal,O Ring (Part No. 3035026) , Seal,O Ring (Part No. 3028291) , Hose,Flexible (Part No. 3349292) , Washer,Plain (Part No. 127018) , Screw,Twelve Point Cap (Part No. 3001811) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 3001340) , Seal,Grommet (Part No. S 1098) , Valve,Check (Part No. 3028324) , Valve,Check (Part No. 3028325) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Seal,O Ring (Part No. 3028291) , Clamp,Hose (Part No. 43828 C) , Hose,Plain (Part No. 63241 F) , Seal,O Ring (Part No. 3028291) , Draincock (Part No. S 962 E) , Hose,Plain (Part No. 3818268) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 3028291) , Hose,Plain (Part No. 3063240) , Clamp,Hose (Part No. 43828 C) , Seal,O Ring (Part No. 3330159) , Gasket,Oil Pan (Part No. 3042590) , Cap,Filler (Part No. 500181) , Gasket,Adapter (Part No. 3073213) , Plug,Pipe (Part No. S 911 B) , Plug,Pipe (Part No. S 911 A) , Plug,Expansion (Part No. 203933) , Plug,Expansion (Part No. 206224) , Plug,Expansion (Part No. 205401) , Insert,Valve (Part No. 3086193) , Pin,Groove (Part No. 3635250) , Guide,Valve Stem (Part No. 3202210) , Insert,Valve (Part No. 3086192) , Valve,Intake (Part No. 3052820) , Valve,Exhaust (Part No. 3088389) , Rotator,Valve (Part No. 3640315) , Spring,Valve (Part No. 5559727) , Collet,Valve (Part No. 205091) , Retainer,Valve Spring (Part No. 205094) , Kit,Engine Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3650900) , Kit,Piston Rings (Part No. Kit2865146) , Sleeve,Wear (Part No. 190397) , Kit,Minor Repair (Part No. 3897385) , Seal,O Ring (Part No. 3897787) , Seal,O Ring (Part No. 3033248) , Resistor,Corrosion (Part No. 4058965) , Valve,Shutoff (Part No. 179901) , Hose,Plain (Part No. 179931) , Clamp,Hose (Part No. 179904) , Valve,Float (Part No. Ar 8629) , Float (Part No. 201022) , Seal,Rectangular Ring (Part No. 3072430) , Screen Fuel Filter (Part No. 154277) , Breather,Fuel Tank (Part No. 68982) , Seal,Grommet (Part No. 206808) , Gasket,Connection (Part No. 3001305) , Retainer,Seal (Part No. 3001301) , Gasket,Connection (Part No. 3032161) , Valve,Shutoff (Part No. 3035346) , Seal,O Ring (Part No. 3279794) , Hose,Flexible (Part No. 3035580) , Bearing,Ball (Part No. S 16002) , Bearing,Ball (Part No. S 16069) , Ring,Retaining (Part No. 70183) , Shaft,Water Pump (Part No. 3042827) , Seal,Oil (Part No. 206948) , Seal,Water Pump (Part No. 4397228) , Impeller,Water Pump (Part No. 205243) , Draincock (Part No. S 962 E) , Ring,Retaining (Part No. 205258) , Connection,Water Inlet (Part No. 3229546) , Brace,Water Pump (Part No. 3036096) , Seal,O Ring (Part No. 145623) , Washer,Plain (Part No. 3005594) , Washer,Lock (Part No. S 604) , Screw,Hexagon Head Cap (Part No. S 103 D) , Screw,Hexagon Head Cap (Part No. S 137) , Screw,Hexagon Head Cap (Part No. 108707) , Plug,Pipe (Part No. S 995) , Gasket,Water Pump (Part No. 3202283) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Housing,Tur Bearing (Part No. 3594555) , Rotor,Shaft Wheel (Part No. 3521033) , Shield,Turbocharger Heat (Part No. 3536588) , Diffuser,Turbocharger (Part No. 3538455) , Inhibitor,Corrosion (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Kit,Lower Engine Gasket (Part No. 4376512) , Kit,Upper Engine Gasket (Part No. 4352578) , Breakdown Services Maintenance For 2Nd Year - Engine Model Kta 19M2 Services - Breakdown Call Visits (No. Of Days In A Year) , Breakdown Part Maintenance For 2Nd Year - Engine Model Kta 19M2 Materials - (1) Stud,Double End Plain (Part No. 3393130) , Gasket,Exhaust Manifold (Part No. 3043097) , Hose,Plain (Part No. 3331403) , Clamp,T Bolt (Part No. 3063809) , Kit,Liner (Part No. 4024767) , Nozzle,Piston Cooling (Part No. 3897840) , Seal,O Ring (Part No. 3866096) , Washer,Plain (Part No. 3025485) , Screw,Twelve Point Cap (Part No. 3025482) , Bushing (Part No. 3002834) , Cleaner,Air (Part No. 4095069) , Gasket,Connection (Part No. 3085804) , Seal,O Ring (Part No. 145607) , Seal,O Ring (Part No. 3081695) , Gasket,Tor Cnv Oil Cooler (Part No. 3065791) , Gasket,Oil Cooler Core (Part No. 206973) , Draincock (Part No. S 962 E) , Kit,Oil Cooler (Part No. 3804934) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 145540) , Gasket,Lub Oil Clr Hsg (Part No. 3065790) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Gasket,Hand Hole (Part No. 3042586) , Seal,O Ring (Part No. 3046201) , Gasket,Hand Hole (Part No. 3042586) , Screw,Captive Washer Cap (Part No. 3040838) , Damper,Viscous Vibration (Part No. 3081040) , Core,Heat Exchanger (Part No. 4019516) , Separator,Fuel Water (Part No. 4095190) , Hose,Flexible (Part No. 4058282) , Seal,O Ring (Part No. 3085709) , Seal,O Ring (Part No. 3046943) , Seal,O Ring (Part No. 3201585) , Hose,Flexible (Part No. Am 6030 Ss) , Hose,Flexible (Part No. Am 6060 Ss) , Screw,Hexagon Head Cap (Part No. S 145) , Nut,Heavy Hexagon (Part No. S 200) , Elbow,Male Adapter (Part No. 68645) , Filter, Oil Bypass (Part No. 3889311) , Shaft,Cam Follower (Part No. 3078218) , Lever,Cam Follower (Part No. 3039164) , Lever,Cam Follower (Part No. 3642503) , Ring,Retaining (Part No. 205439) , Washer,Plain (Part No. 127362) , Screw,Cam Follower Shaft (Part No. 3002886) , Rod,Push (Part No. 3017961) , Rod,Push (Part No. 3057139) , Crosshead,Valve (Part No. 3086362) , Washer,Plain (Part No. 205059) , Screw,Fracture Resistant (Part No. 3032633) , Gasket,Rocker Lever Cover (Part No. 3629140) , Screw,Captive Washer Cap (Part No. 3044413) , Screw,Captive Washer Cap (Part No. 3065950) , Hose,Plain (Part No. 3200316) , Hose,Plain (Part No. 64775) , Clamp,Hose (Part No. 209773) , Clamp,Hose (Part No. 43828) , Gasket,Thermostat Housing (Part No. 3085803) , Thermostat (Part No. 3076489) , Seal,Thermostat (Part No. 188318) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3037537) , Sensor,Temperature (Part No. 3865312) , Sensor,Temperature (Part No. 3865312) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3028291) , Seal,Thermostat (Part No. 186780) , Thermostat (Part No. 4000464) , Screw,Captive Washer Cap (Part No. 3408216) , Screw,Captive Washer Cap (Part No. 3012472) , Indicator,Restriction (Part No. 3637209) , Cup,Injector (Part No. 3279720) , Kit Barrel Plunger & Cup (Part No. Kit3238315) , Pin,Roll (Part No. 203426) , Adapter,Injector (Part No. 4307427) , Seal,O Ring (Part No. 193736) , Tappet,Hyd Var Timing (Part No. 3075381) , Ball,Check (Part No. 167157) , Retainer,Screen (Part No. 174299) , Gasket,Injector (Part No. 173086) , Plug,Injector Orifice (Part No. 3045047) , Plug,Threaded (Part No. 173085) , Screen,Filter (Part No. 3054999) , Retainer,Injector Link (Part No. 3052231) , Connection,Oil Transfer (Part No. 3629341) , Seal,O Ring (Part No. 131026) , Washer,Sealing (Part No. 3023095) , Screw,Banjo Connector (Part No. 3179021) , Screw,Hexagon Head Cap (Part No. 3070962) , Seal,Injector (Part No. 207244) , Screw,Captive Washer Cap (Part No. 3033822) , Hose,Flexible (Part No. Ak10027 Ss) , Gasket,Cover Plate (Part No. 3230948) , Seal,O Ring (Part No. 68910) , Ball (Part No. 3230964) , Seal,O Ring (Part No. 3029820) , Gasket,Cover Plate (Part No. 2884961) , Element,Lub Oil Filter (Part No. 3166554) , Gasket,Oil Trf Connection (Part No. 3228333) , Seal,O Ring (Part No. 3201125) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3036666) , Seal,O Ring (Part No. 3084539) , Draincock (Part No. 214345) , Seal,O Ring (Part No. 3046201) , Seal,O Ring (Part No. 3046201) , Hose,Plain (Part No. 3818271) , Clamp,Hose (Part No. 209773) , Seal,O Ring (Part No. 3035026) , Seal,O Ring (Part No. 3028291) , Washer,Plain (Part No. 127018) , Screw,Twelve Point Cap (Part No. 3001811) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 3001340) , Seal,Grommet (Part No. S 1098) , Valve,Check (Part No. 3028324) , Valve,Check (Part No. 3028325) , Gasket,Fuel Pump (Part No. 3069103) , Spider,Jaw Coupling (Part No. 3046200) , Seal,O Ring (Part No. 3028291) , Clamp,Hose (Part No. 43828 C) , Hose,Plain (Part No. 63241 F) , Seal,O Ring (Part No. 3028291) , Draincock (Part No. S 962 E) , Hose,Plain (Part No. 3818268) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 3028291) , Hose,Plain (Part No. 3063240) , Clamp,Hose (Part No. 43828 C) , Sensor,Pressure (Part No. 5594397) , Sensor,Pressure (Part No. 5594397) , Seal,O Ring (Part No. 3330159) , Sensor,Engine Position (Part No. 4327234) , Module,Electronic Control (Part No. 4354558) , Sensor,Engine Position (Part No. 4327234) , Gasket,Oil Pan (Part No. 3042590) , Cap,Filler (Part No. 500181) , Gasket,Adapter (Part No. 3073213) , Plug,Pipe (Part No. S 911 B) , Plug,Pipe (Part No. S 915 A) , Plug,Expansion (Part No. 203933) , Plug,Expansion (Part No. 206224) , Plug,Expansion (Part No. 205401) , Insert,Valve (Part No. 3086193) , Pin,Groove (Part No. 3635250) , Guide,Valve Stem (Part No. 3202210) , Insert,Valve (Part No. 3086192) , Valve,Intake (Part No. 3052820) , Valve,Exhaust (Part No. 3088389) , Rotator,Valve (Part No. 3640315) , Spring,Valve (Part No. 5559727) , Collet,Valve (Part No. 205091) , Retainer,Valve Spring (Part No. 205094) , Kit,Engine Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3650900) , Kit,Piston Rings (Part No. Kit2865146) , Sleeve,Wear (Part No. 190397) , Kit,Minor Repair (Part No. 3897386) , Kit,Major Repair (Part No. 3897385) , Seal,O Ring (Part No. 3897787) , Seal,O Ring (Part No. 3033248) , Resistor,Corrosion (Part No. 4058965) , Valve,Shutoff (Part No. 179901) , Hose,Plain (Part No. 179931) , Clamp,Hose (Part No. 179904) , Tank,Fuel Transfer (Part No. Ar95856) , Valve,Float (Part No. Ar 8629) , Float (Part No. 201022) , Seal,Rectangular Ring (Part No. 3072430) , Screen Fuel Filter (Part No. 154277) , Breather,Fuel Tank (Part No. 68982) , Seal,Grommet (Part No. 206808) , Gasket,Connection (Part No. 3001305) , Retainer,Seal (Part No. 3001301) , Gasket,Connection (Part No. 3032161) , Turbocharger,Aftermarket (Part No. 4033483) , Valve,Shutoff (Part No. 3035346) , Seal,O Ring (Part No. 3279794) , Hose,Flexible (Part No. 3035580) , Bearing,Ball (Part No. S 16002) , Bearing,Ball (Part No. S 16069) , Ring,Retaining (Part No. 70183) , Shaft,Water Pump (Part No. 3042827) , Seal,Oil (Part No. 206948) , Seal,Water Pump (Part No. 4397228) , Impeller,Water Pump (Part No. 205243) , Draincock (Part No. S 962 E) , Ring,Retaining (Part No. 205258) , Connection,Water Inlet (Part No. 3229546) , Brace,Water Pump (Part No. 3036096) , Seal,O Ring (Part No. 145623) , Washer,Plain (Part No. 3005594) , Washer,Lock (Part No. S 604) , Screw,Hexagon Head Cap (Part No. S 103 D) , Screw,Hexagon Head Cap (Part No. S 137) , Screw,Hexagon Head Cap (Part No. 108707) , Plug,Pipe (Part No. S 995) , Gasket,Water Pump (Part No. 3202283) , Cap,Filler (Part No. 107981) , Bushing,Tachometer Drive (Part No. 100193) , Plunger,Governor (Part No. 3040760) , Driver,Governor Plunger (Part No. 70690) , Plunger,Governor (Part No. 3040750) , Bearing,Thrust (Part No. 3027633) , Stop,Throttle Lever (Part No. 3006343) , Screw,Fuel Pump Adjusting (Part No. 3076040) , Seal,O Ring (Part No. 100478) , Seal,O Ring (Part No. 213768) , Plug,Ball (Part No. 214139) , Ring,Retaining (Part No. 163945) , Screw,Socket Set (Part No. 3046407) , Nut,Regular Hexagon (Part No. S 270) , Screen,Filter (Part No. 146483) , Cap,Fuel Pump Filter (Part No. 201007) , Seal,O Ring (Part No. 145504) , Ring,Retaining (Part No. 128807) , Screw,Drive (Part No. S 2286) , Pump,Gear Fuel (Part No. 3034243) , Bushing (Part No. 3010941) , Shaft,Throttle (Part No. 3010942) , Seal,O Ring (Part No. 70415) , Screw,Socket Set (Part No. 70813) , Nut,Fuel Pump Adjusting (Part No. 110058) , Screw,Socket Set (Part No. 109917) , Spring,Compression (Part No. 153240) , Ring,Retaining (Part No. 70823) , Plunger,Throttle Lever (Part No. 70836) , Washer,Plain (Part No. 70715) , Screw,Knurled (Part No. 70716) , Seal,Dust (Part No. 3010945) , Seal,Wire (Part No. 3003156) , Diaphragm (Part No. 3013811) , Nut,Lock (Part No. 3051461) , Piston,Air Fuel Control (Part No. 3047276) , Piston,Air Fuel Control (Part No. 3047278) , Seal,O Ring (Part No. 3042542) , Seal,O Ring (Part No. 3045986) , Seal,O Ring (Part No. 3066914) , Ring,Retaining (Part No. S 16240) , Screw,Fillister Head Cap (Part No. 70772 B) , Union,Male (Part No. 3032872) , Elbow,Male Union (Part No. 3033023) , Elbow,Male Union (Part No. 3033024) , Solenoid (Part No. 3021420) , Actuator,Etr Fuel Control (Part No. 3408324) , Cover,F P Front (Part No. 3051752) , Gasket Governor Set (Part No. Kitbm68356) , Kit,Turbocharger Repair (Part No. 3545647) , Seal,O Ring (Part No. 3037537) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Coupling,Plain Hose (Part No. 3393349) , Clamp,Hose (Part No. 43828 A) , Seal,O Ring (Part No. 70624) , Housing,Tur Bearing (Part No. 3594555) , Rotor,Shaft Wheel (Part No. 3521033) , Shield,Turbocharger Heat (Part No. 3536588) , Diffuser,Turbocharger (Part No. 3538455) , Inhibitor,Corrosion 10 Liters (Part No. 4926654) , Radiwash 3 Liters (Part No. Ax1013359) , Kit,Lower Engine Gasket (Part No. 4376512) , Kit,Upper Engine Gasket (Part No. 4352578) , Harness,Etr Cnt Mdl Wrg (Part No. 3088290) , Pump,Sea Water (Part No. 3866609) , Camshaft (Part No. 3066882) , Bearing,Camshaft Thrust (Part No. 3007971) , Key,Offset Woodruff (Part No. 200709) , Kit,Turbocharger (Part No. 2882093) , Clamp,V Band (Part No. 3522631) , Core,Aftercooler (Part No. 4910355) , Sensor,Pressure (Part No. 5594397) , Sensor,Engine Position (Part No. 4327234) , Housing,Actuator (Part No. 3084728) , Injector (Part No. 4307428) , Kit,Oil Cooler (Part No. 3804934) , Harness,Etr Cnt Mdl Wrg (Part No. 3088290) , Kit,Water Pump (Part No. 5633548) , Wire,Ground (Part No. 3018924) , Kit,Engine Piston (Part No. 4090013) , Washer,Plain (Part No. 205126) , Screw,Fracture Resistant (Part No. 3013265) , Dowel,Pin (Part No. 69558) , Bearing,Connecting Rod (Part No. 3047390) , Kit,Piston Rings (Part No. Kit2865146) , Kit,Liner (Part No. 4371769) , Gasket,Connection (Part No. 3202117) , Clamp,Hose (Part No. 43828 A) , Hose,Flexible (Part No. Am16025 Nf) , Hose,Flexible (Part No. 3086021) , Seal,O Ring (Part No. 3037537) , Seal,O Ring (Part No. 3922794) , Gasket,Turbocharger (Part No. 206576) , Gauge,Temperature (Part No. 4071818) , Hose,Flexible (Part No. Ak 4030 Ms) , Coupling,Plain Hose (Part No. 3069170) , Coupling,Plain Pipe (Part No. S 1059) , Elbow,Male Adapter (Part No. 68139) , Gauge,Temperature (Part No. 4071823) , Gauge,Pressure (Part No. 4071825) , Pickup,Magnetic (Part No. 4396219) , Harness,Wiring (Part No. 3875359) , Transducer (Part No. 3392445) , Isolator,Vibration (Part No. 102486) , Switch,Temperature (Part No. 4962857) , Switch,Pressure (Part No. 4962841) , Switch,Temperature (Part No. 4962840) , Switch,Temperature (Part No. 4962857) , Sensor,Temperature (Part No. 4926975) , Switch,Temperature (Part No. 4957690) , Valve,Fuel Shutoff (Part No. 3167975) , Tee,Female Pipe (Part No. 70802) , Nipple,Plain Pipe (Part No. S 945) , Bushing,Reducing Pipe (Part No. S 910 C) , Hose,Flexible (Part No. Ak 4016 Ss) , Hose,Flexible (Part No. Ak 4015 Ss) , Gasket,Exh Out Connection (Part No. 2880039) , Washer,Plain (Part No. S 640) , Connection,Exhaust Outlet (Part No. 4084138) , Gasket,Exh Out Connection (Part No. 2880039) , Gasket,Exh Out Connection (Part No. 2880040) , Gauge,Temperature (Part No. 4071818) , Gauge,Temperature (Part No. 4071823) , Gauge,Pressure (Part No. 4071825) , Gauge,Pressure (Part No. 4071832) , Gauge,Temperature (Part No. 4071831) , Gauge,Temperature (Part No. 4071829) , Isolator,Vibration (Part No. 102486) , Washer,Plain (Part No. 102484) , Switch,Push Button (Part No. 504395) , Switch,Key (Part No. 504975) , Switch,Toggle (Part No. 500278) , Coupling,Plain Pipe (Part No. S 1059) , Elbow,Male Adapter (Part No. 68139) , Hose,Flexible (Part No. Ak 4030 Ms) , Coupling,Plain Hose (Part No. 3069170) , Ammeter (Part No. 502881) , Gauge,Pressure (Part No. 4071832) , Gauge,Temperature (Part No. 4071829) , Gauge,Temperature (Part No. 4071831) , Ammeter (Part No. 502881) , Tachometer (Part No. 3231408) , Tachometer (Part No. 2879766) , Tachometer (Part No. 2879766) , Ammeter (Part No. 502881) , Harness,Wiring (Part No. 2865306)

Contact Information