|
Greenhouse. Greenhouse. , Construction Of Green House And Net House As Per Standard Norms Prescribed By National Horticulture Board ( The Specifications For One Block Of 300 M2 ( 300 M2 X 2 Blocks = 600 M2 ) Are Given Below:- , Main Structure: Channel Type Structure Made Of 2M Thick, Gi ( Square Pipe ) Section, Including Cutting, Bended In Required Shape, , Complete As Per Requirements, Design Need To Be Sound Enough To Withstand Wind Speed Minimum 120 Km / Hr And Minimum Load Of 25Kg / M2 Vertical Members: 60X60mm, 47X47mm Roof Truss: 47 X 47Mm, Horizontal Runners Etc, 38 X 38 Mm, Truss Member / Other Support: 32 X 32Mm ± 1Mm , Doors: 1.2 M X 2.5 M Made Of Gi Pipe 2Mm Thickness With Door Closer & All Hardware Accurately Sealed With Door Seal ( Hinge Type ) , Covering: With Clear Standard Polycarbonate Sheet U. V. Stabilized 10 Mm Thick Four Wall For Roof And Sides Fixed With Aluminium Profile And Silicon Sealing ( For Polycarbonate Sheets With Silicon Sealing ) , Shade Screen: Uv Stabilized 50 % Shading Net Folding System With Manually Operated Mechanism For Expanding And Retracting. Size Of Net Should Be Equal To The Floor Area Of Green House. , Fogging System: To Increase The Humidity Up-To 80% ± 5% By Providing 4 Way Fogging Nozzles Hanging Type, With Fine Discharge ( 28-30 Lh ) At 4Bar Pressure, With Pump 2.0 Hp, Disc Filter Etc. Complete, Spacing 1.5X1.5M ( Sand Filter 10 M3 / Hr, Disc Filter 10 M3 / Hr Etc.As Per Requirement. ) , Electric Fitting: Complete Electrical Wiring Of Green House With Copper Wire In Pvc Conduit, Mcb, Main Switch, Light / Power Points As Per Requirement All Fitting / Fixture Should Be Of Isi Marked / Standard Make / Brand, Green House Panel Should Be Connected To Main Power Supply Source ( Approx 100 M ) By Laying Underground / Over Head Armored Conductor Make- Polycab Or Anchor Or Any Isi Standard Make. , Heating Device: Heat Convector With Fan Blower Of Standard Design 2.5 Kw Each To Increase The Temperature During Winter Season. , Cooling System: Evaporating With Fan And With Corrugated Cellulose Coated Cooling Pad 6’’Thick Height 5’, Width, Saturation Efficiency :90%, As Desired Equipped With Anodized Fixed In Aluminium Frame, Water Circulating Pump 1.5 Hp, Co-Axial Fan ( Isi Mark / Bis Standard ) Four No. 1250 Mm Containing 6 Numbers Of Ss Sheet Blades Materials Followed By Aluminium Louver, Maximum Flow ( M3 / H: 23.000, Sound Level : 67Db ( A ) , Axial Fan Belt Driven Slow Speed With 1.5 Hp Single / 3 Phase Motor. Four Air Circulators ( Hanging Type ) Net Cage: To Protected Cooling Pad From Dust And Direct Entry Of Insect Back Side Of Pad Area Should Be Covered With 40 Mesh Net Living 2M Distance With Provision Of Small Door For Maintenance. Curtain And Insect Screen: Roll Up Uv Stabilized 200 Micron Transparent Plastic Film As Curtain Need To Be Provided Upto Height 3.0 M On Pad Sides Having Automatic Type Motor Operated Crank Mechanism System. However Provision For Manual Opening And Closing Of Curtain S Need Also To Be Provided .40 Mesh Insectnet ( Uv Stabilized ) Of Equitant Size Need To Be Fixed Inside The Curtain .Anti Flapping Strip Is Suggested To Insure Smooth Functioning Of Curtain. This Area Is Not Included In 300 M2 And This Is Extra Corridor Area For Maintenance. Make- Quality System Or Agrolt Solutions Or Green Pro Or Any Isistandard Make. , Lighting: Led With Weather Proof Fixture For Visibilitymake- Croma Or Havells Or Syska Or Any Isi Standard Make. , Growing Lights: Led 100W Having Good Quality Range Of Photo Synthetically Active Radiations Distributed Uniformly Across Chamber Make- Croma Or Havells Or Syska Or Any Isi Standard Make. , Control Panel: Programmable Logic Controller Cum Data Logger, Includes Temperature, Humidity And Photoperiodic Monitoring System With Cameras Display : 7 Lcd Touch Screen ( Hmi ) With Interface Computer Screen Regulating / Monitoring Range Temperature : ± 2°C Display: 7” Lcd Touch Screen ( Hmi ) With Interface Computer Screen Regulating / Monitoring Range Temperature: ±2ºc Humidity: ±5% Time: ±5Sec / Day Operation System , Logic And Scada Licence Required : Programmable / User Selectable Temperature: Cooling & Heating To Set Up-To 4 Cycle / Day Humidity : Humidifier / Fogging, To Set Up-To 4 Cycle / Day Light: Rtc Based On / Off 8 Cycle / Day Data Logging : Temperature, Rh, And Lux Data Storing: Up-To 15000 Data With Interval @ 10Min Time Data Transfer: Through Removable Pen Drive / Lan System / Directly To Pc Mountedin Crc Powder Coated Panel Fitted With Contact, Relay, Preventers Sensor Temperature + Humidity 4-20Ma Data Transmitter ( Wall Mounting Type ) Temperature Range: 0-100°C, 1% Humidity Range: 0-100 %Rh, 1.8% Lux Sensor 0-50000Lux, 4-20Ma O / P All Power Supply Used For This System. 1Pc : Desk Top, I5, 8 Gb Ram, 1Tb Hdd 22’’ Tft Monitor 1Ups : Having 1.5-2 Hrs Backup Printer: Multimedia Laser Jet Printer ( All In One ) 1Led: 43’’Make:- Pr Controls Or Quality System Or Agrolt Or Any Isi Standard Make. Contactor Mcb / Auto Manual System , Air Curtain: 3’ Wide Installed Above Door With Auto On / Off Switch Attached With Door , Bench: Hot Dippedgalavaized Steel Support Frame Made Up Of 20 X40mm Rectangular Pipe2mm Thick Size 8’X3’X2.5’ Made Of Gi Pipe, With Gi Mesh Top ( Non Rusted Water Resistance Or As Per Requirements. ) , Earth Work: Excavation In Trenches & Foundation , Foundation: Grouting Of Side Poles ( 1¼’ X 1¼’ X 2.5’ Below Earth Surface In Cement Concrete 1:2:4 ( 1: Cement, 4 Coarse Sand, 4 Stone Aggregate ) , Pcc: 1:5:10 In Foundation , Bricks Wall: With Fps Bricks In 1:6 Cm, All Side Of The Green House2.0’ Above Gl With 1.5’ Below Earthsurface , Plaster: 12Mm Thick In 1:4 Cm ( 1 Cement, 4 Fine Sand ) , Flooring: 40Mm Thick 1:2:4, Anti-Slippery With Proper Drainage Slops. ( In Case Of Benching System Used ) . Floor To Be Raised 2.5Ft By Filing Soil From Existing Level Along With Protected Retaining Wall Complete With Rcc Beam And Rcc Piller. , Plinth Protection:60 Cm Wide 50 Mm Thick 1:3:6 Cc Over 75 Mm Thick Bricks Bat Base All Side Of Green House. Make- Hi-Tech , Painting: Painting Of Walls With 2 Or More Coat Of Apex Exterior Of Approved Colour / Shade , Plumbing Work: For Main Supply 5000 Ltr As Main Feeder Tank Placed On 6-7’ Platform, Which Is Connected To Main Water Source Approx 100M With Necessary Pvc Fitting, 2 X 1000 Lit Misting & Cooling System , Wash Basins: One With Tape & Water Supply Connections, Excess Irrigation With Cocks ( 2 Points ) , Pvc Hose Pipe Of 100’ Length, , Rain Water Harvesting: Gutter 2.0 Mm Thick G.I Sheet Trapezoidal Section, With Pvc Drain Pipe And Connected To Main Water Reservoir Approx 30-40M Make:- Jain Irrigation Or Finolex Or Any Isi Standard Make. , Power Back-Up: There Will Be A Sound Proof ( Acoustic Enclosure ) Power Backup Of 50 Kva Dg Set With Automatic Panel ( For Total Area ) . Installed Undershed Cc Platform And Proper Earthing Make:- Kirloskar Or Koel Or Any Isi Standard Make , Side Vents By Providing 4 Window On Side Wall And Partition Wall Size ( 1.0M X 0.50M ) , Vent Area Will Be Covered With Ss Mesh, Fixed With Aluminium Beading For Complete Area. , Descripation :-Poly Net House: Unit Area: 672 Sqm Length: 24.0M ( Cc ) Width: 28.0 M ( Cc ) Centre Height: 5.5M Gutter Height: 1.0 M Spacing : 6.0 X 4.0 M Buffer Room: Size 4 M X 3 M X 3 M ( L X W X H ) With Double Door System Shape: Dome Shape , Main Column: 76 Mm Od / 2 Mm Thickness Bottom Cord: 48 Mm Od / 2 Mm Thickness Corridor Pipe: 60 Mm Od / 2 Mm Thickness Purlin And Arcs: 42 Mm Od / 2 Mm Thickness Foundation Pipe: 60 Mm Od / 3 Mm Thickness Horizontal And Vertical Member: 33 Mm Od / 2 Mm Thickness , Doors: 2.0M X 1.0M Made Of Anodized Aluminium Section With Door Closer & All Hardware Accurately Sealed With Door Seal , Covering: Roof Covered With Uv Stabilized 200 Micron Transparentplastic Sheet, Along With Wire Netting Coverage Plastic Covered With Net With U.V. Stabilized 50 % Shade Net ( Monofilament ) Fixed With Aluminium Profile And Zigzag Spring Insert. Side Covered With 40 Mess Insect Net ( 120 Gsm ) And Bottom Apron Fixed On G.I. Pipe 42 Mm Od / 2 Mm Thickness With Profile & Spring Make:- Green Pro Or Ginegar Or Suncool ( Any Isi Standard Make ) , Sprinkler System: By Providing Micro Sprinkler Nozzles Hanging Type, With Discharge ( 70-105 Lh ) At 4Bar Pressure, With Pump 1.5 Hp, Disc Filter Etc. Complete, Spacing 3.0 X 3.0 M Make:- Jain Irrigation Or Finolex Or Any Isi Standard Make. , Foundation: Grouting Of Side Poles ( 45X45x90 Cm ) Below Earth Surface In Cement Concrete 1:2:4 ( 1: Cement, 4 Coarse Sand, 4 Stone Aggregate ) , Pcc: 1:5:10 In Foundation , Bricks Wall: With Fps Bricks In 1:6 Cm, All Side Of The Green House ( Hi-Tech ) 1.5’ Above Gl With 1.5’ Below Earthsurface , Plaster: 12Mm Thick In 1:4 Cm ( 1 Cement, 4 Fine Sand ) , Plumbing Work: For Sprinkler System With Necessary Fitting Pvc Pipe, Polymer Tank1000 Lit And Connected To Main Storage Tank , Flooring: 40Mm Thick 1:2:4, Anti-Slippery With Proper Drainage Slops. Floor To Be Raised 2.5Ft By Filing Soil From Existing Level Along With Protected Retaining Wall Complete With Rcc Beam And Rcc Piller. , Plinth Protection:60 Cm Wide 50 Mm Thick 1:3:6 Cc Over 75 Mm Thick Bricks Bat Base All Side Of Green House. ( Hi-Tech ) , Bench: For Primary Hardened Tray- Hot Dippedgalavainzed Steel Support Frame Made Up Of 20 X40mm Rectangular Pipe 2 Mm Thick Movable Size 8’X3’X2.5’ Made Of Gi Pipe, With Gi Mesh Top ( Non Rusted Water Resistance ) . , Trellising System :Base Wire 8Mm , Trellising Wire :3Mm Steel, Supporting Wire : 4Mm Steel , Storage Water Tank : Above Ground 10Ft. 5000 Lt. , Storage Room : 12’-14’-12’ With Side Walls With Lantered Roof , Washing Pit -10’- X 2’-6’’ X 3’ Covered With Shed , Gutter:- 2Mm Thickness, Suitable Levelling With Proper Drainage Connectivity Pvc Pipe. , Shade Screen: Uv Stabilized 50% Shading Net Folding System With Manually Operated Mechanism For Expanding And Retracting. Size Of Net Should Be Equal To The Floor Area Of Green House. Make:- Tufflex Or Krushi Net Or Green Pro Or Any Isi Standard Make. , Trays 10000 ( 99Square Holes ) , Cocopeat 30 Qtls Low Ec , Perlite 10 Qtls , Vermiculite 10 Qtls
|
